Stainless steel rolling shutter door needs our careful care! At present, this kind of stainless steel rolling shutter door plays an important role in our production and life. It is made of high-quality stainless steel and has advantages in various aspects in practical application. Here are the maintenance methods of stainless steel rolling shutter door.

一方面，我們在平時不銹鋼卷簾門的過程中，應定期檢查不銹鋼卷簾門的固定軌道支架結構，如：支架出現松動，應及時擰緊螺栓。將不銹鋼卷簾門關閉，檢查軌道是否存在凹陷或者彎曲的現象，如發現有變形的現象，需要用橡皮手錘敲打變形地方加以校正，如軌道的損壞程度嚴重，必須立即更換新的軌道結構。

On the one hand, in the process of stainless steel rolling shutter door, we should regularly check the fixed track bracket structure of stainless steel rolling shutter door, such as: if the bracket is loose, the bolt should be tightened in time. Close the stainless steel rolling shutter door and check whether the track is sunken or bent. If the deformation is found, it is necessary to knock the deformed place with a rubber hammer to correct it. If the track is seriously damaged, a new track structure must be replaced immediately.

同時還要全面檢查所有松動部位并及時擰緊。在上掀門上，檢查安裝彈簧平板，確保螺釘已旋緊，將變松螺釘擰緊。檢查所有的鉸鏈，將所有變松螺釘擰緊，將受損鉸鏈更換成新件。

At the same time, check all loose parts and tighten them in time. On the upper lift door, check and install the spring plate, make sure the screw is tightened, and tighten the loose screw. Check all hinges, tighten all loose screws and replace damaged hinges with new ones.

濟南卷簾門

Jinan roller shutter door

另一方面，我們在平時不銹鋼卷簾門的過程中，對不銹鋼卷簾門軌道的清潔與潤滑操作作，可利用高濃度的家用洗滌劑來清洗其軌道，去除表面的污垢和硬化油脂。此時需注意將轉軸的位置，一定要徹底清洗干凈，然后再將不銹鋼卷簾門的軌道及轉軸位置擦干凈。

On the other hand, in the process of stainless steel rolling shutter door, we can use high concentration household detergent to clean and lubricate the track of stainless steel rolling shutter door to remove the dirt and hardening grease on the surface. At this time, it is necessary to pay attention to the position of the rotating shaft, and then clean the track and shaft position of the stainless steel rolling shutter door.

對于潤滑，可利用石墨粉撒在軌道上，用家用潤滑油或者是硅樹脂噴涂在轉軸上或是在軌道以及轉軸上，噴灑不銹鋼卷簾門專用的潤滑油噴劑，從而來獲得良好的潤滑程度。如果不銹鋼卷簾門上安裝有滑輪結構的話，我們需要使用與轉軸上使用相同的潤滑劑對其加以潤滑，保證不銹鋼卷簾門各部件的良好潤滑條件，使其可靠運行。

For lubrication, graphite powder can be used to sprinkle on the track, household lubricating oil or silicone resin is used to spray on the rotating shaft or on the track and rotating shaft, and the special lubricating oil spray for stainless steel rolling shutter door can be sprayed, so as to obtain a good degree of lubrication. If the pulley structure is installed on the stainless steel rolling shutter door, we need to use the same lubricant as the rotary shaft to lubricate it, so as to ensure the good lubrication conditions of all parts of the stainless steel rolling shutter door and make it operate reliably.